COUNTRYSIDE® CORN/WOOD PELLET STOVE /FIREPLACE INSERT Safety tested and EPA exemption tested by Warnock Hersey to UL 1482, CAN/ULC-S627, ULC-S628, APF
10 The stove must be installed with the following minimum clearances to side and back wall combustible materials. NOTE: These are minimum clearanc
11 It is recommended that only an authorized Countryside installer install your pellet/corn stove. The following installation guidelines must be f
12GUIDELINES FOR EXHAUST VENTING SYSTEMS DESIGN, CONT…… To determine whether a 3” or 4” exhaust system should be used, follow the guidelines below:
13 OUTSIDE MAKE-UP AIR FOR COMBUSTION IS REQUIRED ON ALL INSTALLATIONS 1) For FREESTANDING installations with horizontal through-the-wall exhaust
14 The Countryside Corn/Pellet Stove Model J3500/3500P may be installed as follows: 1) A freestanding unit (with a pedestal only) 2) A hearth mo
15ALCOVE INSTALLATION REQUIREMENTS The Countryside is approved for the standard alcove height of 72 inches, or for a reduced alcove height with a mi
16FREESTANDING STOVE INSTALLATION REQUIREMENTS Horizontal Exhaust Termination: 1) Locate proper position for the type “PL” wall thimble (F). Use
17 Locate so that exhaustdoes not interfere withfresh air Storm Collar Required Required
18 WARNING: Unless the venting is enclosed and insulated this installation will cause poor venting and serious creosote buildup in cold climate area
19FIREPLACE INSERT INSTALLATION REQUIREMENTS The Countryside Model 3502 Fireplace Insert may be installed in a masonry factory built fireplace or on
2TABLE OF CONTENTS PAGE CLEAN BURN (special additive) & ESTIMATED FUEL FEED RATE CHART………….. 3-4 INTRODUCTION & SPECIFICATIONS………….……………………
20FIREPLACE INSERT INSTALLATION CONTINUED…… The Countryside Model 3502 Fireplace Insert requires a fireplace shroud for proper installation. The sh
21 Your Countryside Corn/Pellet Stove comes to you with the glass door installed in place, ready for use. The glass is surrounded on the edges wit
22 Front view left view Side view showing control operation Adjustable Air Deflector Move up or down
23 9 Turn the Fuel Stirrer knob to the number 1 setting and let it rotate a couple turns to stir the firestarter and wood pellets t
24 Startup When the circuit board is energized (unit plugged in) there is a 15 second purging of the auger tube to allow fuel to enter the firepot.
25 A proper draft setting is crucial to the successful burning of solid fuels. Draft refers to the amount of air flowing through the burn chamber
26MAINTENANCE INSTRUCTIONS CONTINUED… 9 While you are tapping the side heat exchangers, we recommend that you pull the draft knob all the way out
27WEEKLY MAINTENANCE 9 Set the stove on high fire. Open the draft to 100% and allow the stove to burn for 15 minutes. Resume desired heat and dra
28 9 Power Outage During a power outage, the stove will shut down safely. It will not automatically restart when the power returns, unless t
29 9 The Countryside can be installed with and operated by a wall-mounted thermostat. However, a wall thermostat is not provided with the stove.
3 CLEAN BURN CORN ADDITIVE TM AMERICAN ENERGY SYSTEMS INC. HAS DEVELOPED AN ADDITIVE THAT WHEN MIXED WITH CORN VIRTUALLY ELIMINATES THE (CLIN
30 PROBLEM CAUSES SOLUTIONS ? Fire burns with a lazy, orange flame and/or fuel builds up in the grate and the window gets sooted up. ♦ Insuff
31PROBLEM CAUSES SOLUTIONS ? Fire goes out or stove shuts down automatically. ♦ Hopper is empty. ♦ Fuel is not feeding. ♦ High limit tempera
32PROBLEM CAUSES SOLUTIONS ? Blower will not operate. ♦ No power to stove. ♦ No power to control board. 9 Check to see that th
33PROBLEM CAUSES SOLUTIONS Fuel burns off to quickly, have difficulty keeping a pilot fire. Air shutter is open to far. Over drafting on a vertica
34Countryside Wiring Diagram (Ortech Circuit Board) MF3537 low temperature normally open 110 deg. snap disk thermostat MF3537 normally op
35 If the low fire heat setting is too low for the fuel that you are burning and the fire goes out, the number 1 or 2 heat setting can be adjusted
36NEW AIR WASH SYSTEM FOR COUNTRYSIDE UNITS NOTE: These adjustments should only be made by a qualified technician The new air wash system is an i
37DRAFT SLIDE GATE ADJUSTMENT The normal operation of the Countryside would be with the Draft Slide Gate open
38 5 YEAR LIMITED WARRANTY This warranty is issued by American Energy Systems, Inc. (Manufacturer) and extends only to the original purchaser of thi
39SERVICE RECORD DATE SERVICE OR CLEANING PERFORMED
4COUNTRYSIDE TECHNICAL DATA ESTIMATED FUEL FEED RATE CHART CORN: Fuel consumption will vary depending on Kernel size and moisture content Heat S
5DEAR VALUED COUNTRYSIDE OWNER, We appreciate your decision to help preserve our precious environment by purchasing the Countryside Corn/Wood Pellet
6 IMPORTANT: Proper installation of this stove is crucial for proper and safe operation. Installing this product improperly may result in a hou
7 Unlike petroleum and natural gas products, solid fuels such as corn and wood pellets create ash as the fuel is burned. Even with the highly eff
89 There are many varieties of corn grown around the world. Each variety has unique characteristics including the shape and size of the kernel. Yo
9The Pedestal Ash Pan unit comes completely assembled, the Insert comes with the shroud packaged separately and the Leg unit comes with the Legs pack
Kommentare zu diesen Handbüchern